Posts

2019 Maple Syrup Season Recap

Image
The 2019 maple syrup season is officially over in the greater Pittsburgh area.  Overall it was a great year.  We enjoyed our new homemade evaporator and our new homemade RO.  

In 2019 we had 36 taps and produced a little over 6.25 gallons of syrup.  The majority of the syrup was golden, with a very small amount of amber (a couple of quarts) and only two small batches of dark (less than 24 ounces) at the very end.  Overall this is very good considering most of our trees are red maples and we had a pretty consistent 64:1 ratio for sap to syrup (collected just over 400 gallons of sap on the season).

Now its time for maple festivals! This year we will be entering syrup for all three grade A classifications, golden delicate, amber rich, dark robust.  
Check back after April 26th to see how our syrup did!

Be sure to check out your local maple festivals.  Here are some links to a couple of great ones!

The Geauga County Maple Festival in Chardon, Ohio

The Pennsylvania Maple Festival in Meyersdale, …

End of Season Equipment Cleaning

Image
When then maple sugaring season has come to a close, there is a lot of cleanup and storage that needs to be done so that everything is well maintained and kept in order for the next season.  In this post we will discuss tips for cleaning the following maple equipment:
Evaporator panReverse Osmosis (RO) cleaning and storageBuckets & lids (collection and gathering)SpilesCollection / gathering tanksThe required items and process steps are outlined below and are accompanied by instructional videos. 
Evaporator Pan Things you will need: White vinegarWater (preferably permeate or distilled)Non-abrasive cleaning cloth or large scrub brushBaking sodaGarden hose or pressure washer (optional)Detergent free SOS/scouring pad (optional)Process: First, make sure your pan has been drained of all sap and syrup.  Premix a 50/50 blend of white vinegar and hot permeate (if you used an RO system during the year), distilled water, or tap water (as last choice due to potential chlorine).  For smaller, flat …

Indicators Maple Syrup Season is Over

Image
How do you know when maple syrup season is over?  There are a few typical things that bring the season to a close:
Weather - it just gets too warm and there are no more freeze/thaw cycles that cause the sap to run. Also, extended warm weather periods increases bacteria in the tap hole and can significantly lessen or stop sap flow.  Trees - sometimes they just shut down and stop running even if you are still getting some decent freeze/thaw patterns.  This is pretty typical behavior for red maplesBudding - the trees are beginning to bud and will soon be dawning their leaves for the year.  As the buds break and photosynthesis begins, this causes changes to the sap, negatively impacting the flavor of the syrup.  This is frequently called "buddy", a type of "off" flavor.  Below is a video covering the basics of knowing when your season is wrapping up and shows examples of red maple and sugar maple buds late in the season.  




How to Make a Maple Stir from Pure Maple Syrup

Image
Nothing is sweeter than a delicious maple stir. Today we are going to show you how to make one from pure maple syrup. 



Things you will need:
Pure maple syrup (8 oz. makes about 4 stirs)Stainless steel potCandy thermometer (goes to minimum of 240°F)Bowls and spoonsProcess Heat the pure maple syrup in the pot to 235°F.  Be very careful to prevent the syrup from foaming up and boiling over and out of the pot.  Adjust the heat as necessary to prevent this, yet still raising the temperature of the syrup.  Promptly remove the syrup from the heat at 235°F, allowing it to cool in the pot to 175°F.  This will take approximately 10 minutes.Pour approximately 1.5 - 2 oz of syrup into each bowl and begin stirring quickly. Syrup will start to thicken and lighten in color as it sets up into a creamy treat.Enjoy! 

Custom Hobby Maple Syrup Evaporator

Image
This year I designed and built a custom hobby maple syrup evaporator to improve efficiency and increase the volume of syrup we could produce.  In this post I will outline some of the design and build process.  

Specs and Features
Number of taps: 10 - 50Max main pan volume: 27 gallons (29.5" long x 21.5" wide x 10" deep)Recommended batch size: 5 gallons (sap or concentrate)Evaporation rate: 4 gallons/hour for 5 gallon batchFuel type: Natural Gas (can be converted to propane with different orifice)Thermal output: 210,000 - 270,000 BTUsBurners: three (3) stainless steel U-burnersPiezoelectric ignitionIndependent burner valves and air/gas mixing chambersLid: stainless steel tiltable with steam catch channelDraw-off: gate valve over a mountable 6" deep full-size stainless steel steam table panSteam table pan volume: 5 gallons

Description 

The evaporator was designed and built for approximately 25 - 50 taps, but can accommodate as little as 5 gallons of sap per batch in the …

Maple Syrup and Natural Gas - Murrysville PA History

Image
Murrysville, PA is home to the nation's first commercial natural gas well, which remained the largest gas well in the world for many years. However, the origin of how this gas well, and the entire natural gas industry came to be is especially interesting, particularly to anyone who lives in Murrysville or enjoys maple syrup.  
The Haymaker brothers (Michael and Obediah) grew up in the Murrysville, PA area, and were working in the oil industry in Clarion County, PA in 1876.  Convinced there was oil in Murrysville in 1877 they leased farm land from Henry Remaley and constructed a wooden derrick and began drilling.  Overcoming many hardships and financial issues, the brothers finally broke through on November 3, 1878.  In the words of Michael Haymaker in a 1936 interview, 
"I'll never forget the day the well came in.  We were down 1400 feet.  Without the slightest warning, there was a terrific roar and rumble that was heard fifteen miles away.

Every piece of rigging went sky hi…

2019 Maple Sugaring - Scaling Up

Image
The 2019 maple sugaring season has been in full swing for approximately three weeks and we have already produced more than 3 times the syrup we did in 2018.

This year we scaled up significantly, tapping 6 times as many trees.  We built a custom natural gas evaporator and reverse osmosis (RO) system to deal with the increase in sap.

So far the setup has been working great, with evaporation rates reaching 4 gallons per hour after cutting 50% of the water out of the sap with the RO.

The weather seems to be cooperating and after a cold spell early this week we should be boiling Wednesday through Saturday!